1. 中科聚峰礦井車設備

        • 服務熱線:

          15065707252

        當前位置:首頁 > 新聞中心 > 常見問題 >

        新聞中心

        服務熱線電話

        15065707252

        井下裝載機轉向失靈可以采取什么措施?

        來源:http://www.socialsecurityutah.com/ 發布時間:2022-04-13 瀏覽次數:200

        內容詳情:
        井下指揮車在工地上越來越受到歡迎,它的使用效果是非常值得認可的,即使工作的環境是非常的惡劣,但是其使用效果也是非常好的。那么,在惡劣條件下工作肯定也免不了會出現故障,就想我們在使用的時候會遇到轉向失靈的問題,這是一個比較嚴重的現象,也是比較危險的,所以接下來我們就來介紹一下在遇到這種情況的時候有哪些應對措施。
        Underground command vehicle is becoming more and more popular on the construction site, and its use effect is very worthy of recognition. Even if the working environment is very bad, its use effect is also very good. Then, it is inevitable that there will be failures when working under bad conditions. I think we will encounter the problem of steering failure when using it. This is a serious phenomenon and dangerous, so let's introduce the countermeasures when we encounter this situation.
        由于井下指揮車使用過程中,出現過轉向失靈故障,方向盤轉不動,或者用力才能轉動一點。轉向是由液壓轉向器控制的,首先檢查是否是液壓轉向器內部機械卡死,拆開轉向器,看有沒有發現任何零件脫落卡住現象。
        During the use of the underground command car, there was a steering failure, and the steering wheel could not rotate, or it could only rotate a little with force. The steering is controlled by the hydraulic steering gear. First, check whether the internal machinery of the hydraulic steering gear is stuck. Disassemble the steering gear to see if any parts fall off and get stuck.
        再檢查發現轉向器閥塊的進油口是否有小塊顆粒狀雜物,將進油口附近的單向閥堵住。清理干凈雜物后,轉向器即恢復正常。
        Then check whether there are small granular sundries at the oil inlet of the steering gear valve block, and block the check valve near the oil inlet. After the sundries are cleaned, the steering gear will return to normal.
        因此,當其他井下指揮車出現類似故障時,很快就排除。對這些雜物來源作了調查,原來液壓系統回油管路上有個線隙濾油器,使用的一種粘合劑易脫落,脫落的顆粒順著回油管到油箱,再經油泵到轉向器,滯留在單向閥上造成故障。
        Therefore, when other underground command vehicles have similar faults, they will be eliminated soon. The sources of these sundries were investigated. There was a line gap oil filter on the oil return pipeline of the hydraulic system. An adhesive used was easy to fall off. The fallen particles went along the oil return pipe to the oil tank, then to the steering gear through the oil pump, and remained on the one-way valve, causing failure.
        為了減少轉向失靈的現象,在使用指揮車的液壓系統上的任何元件,都不應使用易脫落或被液壓油浸泡后會成碎片的材料制作,避免因材料不好造成的堵塞,液壓元件生產廠家尤應重視。
        In order to reduce the phenomenon of steering failure, any component on the hydraulic system of the command vehicle should not be made of materials that are easy to fall off or will become fragmented after being soaked in hydraulic oil, so as to avoid blockage caused by poor materials. The manufacturer of hydraulic components should pay particular attention to it.
        以上就是為大家介紹的有關井下裝載機的詳細介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以專業的態度,為您提供服務http://www.socialsecurityutah.com
        The above is a detailed introduction to the underground loader. I hope it will help you If you have any questions, please contact us We will provide you with professional service http://www.socialsecurityutah.com
        久久精品国产2020观看福利